Product ID:3860-1 WASH PRIMER ACTIVATOR
MSDS Date:01/01/1991
FSC:8010
NIIN:00N026230
MSDS Number: CFLNS

CARDINAL INDUSTRIAL FINISHES

16030 PHOENIX DR
CITY OF INDUSTRY, CA 91745
US

Emergency Phone: 800 424-9300 (CHEMTREC)

Info Phone: 818-444-9274

Preparer: RICHARD STEWART

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

1.0 @ 68F

CAS: 1336-21-6

RTECS: 9999999VO

Fraction By Weight: <5.0%

OSHA PEL N/K

ACGIH TLV: N/K

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

5.7 @ 68F

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: <5.0%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3/3 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: MAY CAUSE NASAL
IRRITATION, HEADACHE, DIZZY, NAUSEA & VOMIT. EYES: CAN CAUSE IRRIT,
REDNESS, TEARING & BLURRED VISION. SKIN: CAN DRY & DEFAT SKIN
CAUSING CRACKS, IRRIT & DERM, PROLONGED EXPOSURE MAY BE TOXIC.
INGEST: CAN CAUSE GI IRRIT, VOMIT, NAUS & DIARRHEA. MAY CAUSE
HEADACHE, WEAK. MODERATELY TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY TRACT IRRITATION,
DERMATITIS, NAUSEA, AND VOMITING.

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION IMMEDIATELY. SKIN: WASH EXPOSED AREA WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING. INHALATION: REMOVE TO FRESH AIR. IF
BREATH ING IS DIFFICULT, ADMINISTER OXYGEN. IFBREATHING HAS
STOPPED, GIVE ARTIFICIAL RESPIRATION. INGESTION: INDUCE VOMITING.
KEEP PERSON WARM AND QUIET. GET MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:>212F,>100C
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SHOULD BE NOT BE USED EXCEPT AS FOG TO KEEP
CONTAINERS COOL.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE WHEN EXPOSED TO
SEVERE HEAT OR FIRE. DECOMPOSITION OF PRODUCT DURING FIRE MAY
PRODUCE TOXIC FUMES.

Spill Release Procedures:REFER TO OTHER SECTIONS. ELIMINATE ALL
IGNITION SOURCES, ABSORB LIQUID IN ABSORBENT MATERIAL AND PREVENT
SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CONTRS OF THIS MATL MAY BE HAZ WHEN
EMPTIED. SINCE EMPTIED CONTRS RETAIN PROD RESIDUALS (VAP, LIQ, &/OR
SOLID), ALL HAZ PREC IN MSDS MUST BE OBSERVED.
Other Precautions:PAINT & SOLVENTS HAVE BEEN LINKED TO LIVER
ABNORMALITIES, KIDNEY & LUNG DAMAGE. ALTHOUGH THIS COATING IS
WATERBORNE OF LOW TOXICITY, FOLLOW PRECAUTIONS OF THIS MSDS TO
PREVENT OVEREXPOSURE.

Respiratory Protection:IF TLV OF THE PRODUCT/ANY COMPONENT IS EXCEEDED,
A NIOSH APPROVED AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF ENVIRON
CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH APPRVD RESPS UNDER
SPECIFIED CNDTNS (SEE YOUR SAFETY EQUIP SUPPLIER). (SUP DAT)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:PVA OR POLYETHYLENE.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
SHOWER . PREVENT RPTD/PRLNG SKIN CONT W/GB PROT HANDCREAM, WEAR
(SUP DAT)
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOM,
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
RESPIRATORY PROTECTION: ENGINEERING/ADMINISTRATIVE CONTROLS SHOULD BE
IMPLEMENTED TO REDUCE EXPOSURE. OTHER PROTECTIVE EQUIPMENT:
IMPERVIOUS CLOTHING AND CHEMICAL RESISTENT BOOTS.

Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.0 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SOLUBLE
Appearance and Odor:GRAY LIQUID, AMMONIA AND SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
AVOID CONTAMINATION WITH ALKALIES. CONTACT WITH STRONG OXIDANTS MAY
CAUSE FIRE AND EXPLOSIONS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES, POOR
VENTILATION, CORRROSIVE ATMOSPHERE, EXCESSIVE AGING.
Hazardous Decomposition Products:BURNING MAY PRODUCE CARBON DIOXIDE
AND/OR CARBON MONOXIDE.

Waste Disposal Methods:DESTROY BY LIQUID INCINERATION IN ACCORDANCE
WITH APPLICABLE REGULATIONS. CONTAMINATED ABSORBENT MAY BE
DEPOSITED IN A LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.